Product ID:50-1 WHITE, BREAK-THROUGH
MSDS Date:01/01/1992
FSC:6810
NIIN:00N025804
MSDS Number: BPGPL

VANEX COLOR INC

1700 S SHAWNEE STREET
MT VERNON, IL 62864
US

Emergency Phone: 618-244-1416

Info Phone: 800-851-7390

Preparer: BATRICE BLACKMON

Cage: HO921

VANEX COLOR INC

MT VERNON, IL 62864 US

Telephone: 800-851-7390

Cage: HO921

(ETRACTED FROM DHHS (NIOSH) PUBLICATION NO. 90-118) .

RTECS: 9999999ZZ

RESPIRATORY SYMPTOMS DEVELOP, CONSULT MD.

RTECS: 9999999ZZ

W/ADMIN OF ETHYLENE GLYCOL MONOBUTYL ETHER (EGBE)

RTECS: 9999999ZZ

O.6 @ 68F.

CAS: 111-76-2

RTECS: KJ8575000

Fraction By Weight: 9%

OSHA PEL S, 50 PPM

ACGIH TLV: S, 25 PPM; 9293

PHTHALIC ACID, DIBUTYL ESTER; (DIBUTYL PHTHALATE) (SARA

CAS: 84-74-2

RTECS: TI0875000

Fraction By Weight: 2%

OSHA PEL 5 MG/M3

ACGIH TLV: 5 MG/M3

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHAL:VAP OF THIS MATL MAY IRRIT NOSE,
THROAT, & RESP PASSAGES. HIGHER CONC CAN INDUCE HDCH, DIZZ/NAUS,
DROWS, & SHORTNESS OF BREATH. SKIN:NO IRRIT IS LIKELY TO DEVELOP
FOLLOWING SHORT CNTCT PERIODS W /HUMAN SKIN. PRLNG/RPTD EXPOS CAN
LEAD TO REDNESS/SWELLING/NECROSIS. EYE:CAN INDUCE PAIN & MOD
IRRIT(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:SKIN ABSORP:ADVERSE SYSTEMIC EFTS CAN
DEVELOP FOLLOWING RPTD/PRLNGD CONTACT W/HUMAN SKIN. INHAL OF HIGH
CONC OF VAP CAN INDUCE ANEMIA, LIVER & KIDNEY INJURY & CLOUDING OF
CORNEA. ACUTE:CAN CA USE UPPER RESP IRRIT. CHRONIC:PRLNGD OVEREXPOS
BY INHAL MAY CAUSE DELAYED LUNG INJURY/DISEASE (SILICOSIS) (SUPP
DATA)
Medical Cond Aggravated by Exposure:PULMONARY AND/OR RESPIRATORY
DISEASES.

First Aid:SKIN:REMOVE CONTAM CLTHG & FOOTWEAR. WASH MATL OFF SKIN
W/SOAP & H*2O. IF REDNESS, ITCHING/BURNING SENSATION DEVELOPS, GET
MD ATTEN. WASH CONTAM CLTHG & DECONTAM FOOTWEAR BEFORE REUSE.
EYE:IMMED FLUSH W/WATER FOR AT LEAST 15 MIN & HAVE EYEEXAMINED &
TREATED BY MD PERS. INGEST:GIVE 1 OR 2 GLASSES OF WATER TO DRINK.
INDUCE VOM. REFER VICTIM TO MD. INHAL:REMOVE TO FRESH AIR. IF
COUGH/OTHER (ING 6)

Flash Point Method:CC
Flash Point:210F,99C
Lower Limits:0.5%
Upper Limits:10.6%
Extinguishing Media:ALCOHOL FOAM, CO*2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NO UNUSUAL FIRE/EXPLOSION HAZARDS ARE
KNOWN FOR THIS PROD. AS TYPICAL OF CLOSED CONTAINERS CONTAINING
LIQUID, THEY MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.

Spill Release Procedures:DIKE AND CONTAIN SPILL WITH INERT MATERIALS
(SAND, CLAY, EARTH, ETC). TRANSFER THE LIQUID TO CONTAINER FOR
RECOVERY OR DISPOSAL. KEEP SPILL OUT OF SEWERS AND OPEN BODIES OF
WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP FROM FREEZING. KEEP AWAY FROM
HEAT/OPEN FLAME. AVOID BRTHG VAP. AVOID CONTACT W/EYES/SKIN &
CLTHG. USE W/VENT ADEQ TO MAINTAIN VAP (SUPP DATA)
Other Precautions:HAZ INGRED NOTATED IN INGRED SECTIONS AS "SUBJECT TO
SEC. 313" ARE SUBJECT TO RPT REQ UNDER SECTION 313 OF EMER PLANNING
& COMMUNITY RIGHT-TO-KNOW ACT OF 1986 & OF 40 CFR 372.

Respiratory Protection:IF TLV OF THE PRODUCT OR ANY COMPONENT IS
EXCEEDED, USE A NIOSH/MSHA APPROVED RESPIRATOR. IF VAPOR EXPOSURE
CAUSES EYE DISCOMFORT, USE A NIOSH/MSHA APPROVED FULL-FACE
RESPIRATOR.
Ventilation:PROVIDE GENERAL AND/OR LOCAL EXHAUST VENTILAITON TO CONTROL
AIRBORNE LEVEL BELOW THE EXPOSURE GUIDELINES.
Protective Gloves:IMPERVIOUS GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING AND SHOES.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING IMMEDIATELY. WASH
SKIN WITH SOAP AND WATER. LAUNDER CLOTHES BEFORE REUSE.
Supplemental Safety and Health
HDLG/STOR PREC:CONC BELOW TLV. CNTNRS MAY BE HAZ WHEN EMPTIED-ALL HAZ
PREC MUST BE OBSERVED. KEEP OUT OF REACH OF CHILDREN. EFTS OF
OVEREXP:TAKE APPROP MEASURES TO AVOID BRTHG DUST. ANIMAL STUDIES
HAV E CLEARLY DEMONSTRATED DOSE-RELATED EFTS ON CNS, HEMATOPOIETIC
TISS/BLOOD/KIDNEYS, LIVER ASSOC(ING 3)

HCC:N1
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:SEE ING
Vapor Density:HVR/AIR
Spec Gravity:1.1-1.3(H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:MISCIBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL & HYDROFLUORIC ACID.
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:COMBUSTION PRODUCT:CO*2, CO

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REQUIREMENTS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.